Reference no: EM13181013
An appropriate correlation for heat transfer by natural commotion from a honzontal pipe to the atmosphere is
Nu = 033Gr0.25PPr0.25
Show that the above correlation can be simplified to
when air has the values listed bclow
3.077x10-3K-1, ρ = 1.086 kg m-3, cp at 1.083 kg m-3 k=2.816x10-5 kWm-1K-1, μ = 1962 x10-5 kg m-1s-1
(d) The outer surface of the insulation on a horizontal steam pipe has a radius of 50 mm and is at a termxratim of 90°C. The atmospheric air surrounding the pipe is at a temperature of 14°C. and has the property s alms listed in part (c) above. Estimate the rate of heat loss by natural convection to the atmosphere by cach metit length of pipe.
2. (a) Explain how hcat is lost from a hot surface to the swrounding air.
(b) (i) Explain the effect of insulating a hot surface.
(ii) What is meant by the economic thickness of lagging?
(c) What is the purpose of a silvered coating. usually of a good conductor. m the outside of most insulation?
3. Butanol at a tcmperaturc of 28°C is pumped at a velocity of 14 ms-1 through a 100 mm diameter tube kept at a wall temperature of 90°C. The properties of butrol are given below.
Determine the connective heat transfer coefficient (you will find the appropriate correlation in the lessons).
Data:
p = 950 kg m-3
cp = 2.142 kJ kg-1 K-2
μ = 29 x 10-3 kg m-2 s-1 at 28°C
μ = 12 x 10-3 kg m-1s-1 at 90oC
k = 2.4 x10-4 kW m-1 K-1
4. Liquid ammonia is heated as it flows at a mean velocity of 2 ins-1 through a circular pipe. The pipe, which has an internal diameter of 75 nun. is at a uniform temperature of 27°C. and the ammonia at a section 1.2 m from the inlet to the pipe has a temperature of -23°C. Use the following information to estimate the local heat transfer flux at I = 12 m. Note, the properties of ammonia liquid base been taken a -23°C, except whew stated.
Liquid ammonia properties:
Density = 600 kg m-3
Specific heat capacity = 4.86 kJ kg-1 K-1
Dynamic viscosity (at 27°C) = 1.19 x 10-4 kg m-1 s-1 Dynamic viscosity = 2D5 x 104 kg m-1 s-1
Thermal conductivity = 5.11 x 10-4 kW nr1 s-1
Heat transfer conelations:
5. (a) Explain what is meant by an overall heat transfer coefficient.
(b) Explain what is mean by failing and what its effect will be on the value of the overall heat transfer coefficient.
(c) A heat exchanger is to be used to heat a ;micas liquid within the tubes using saturated steam at 100°C. The tubes have an inside diameter of 20 min and outside diameter of 22 trim. it is estimated that the imer surface heat transfer coefficient will be 42 kW m-2 K-1 and the mot surface heat transfer coefficient will be 15A kW m-2 K-1 when the exchanger is clean. In order to allow for possible fouling dining use you should assume a fouling factor of 1.12 x 10-4 m2 K W-1 will be applicable.
Estimate:
(i) the overall heat transfer coefficient in use
(ii) the heat transfer rate when the relevant average temperature difference between steam and fluid is 50°C and the heat exchanger has 100 tubes each of 5 m in length.
|
What uses of resources the strategies would allow
: Imagine your company has put you in charge of developing a sustainability plan, a common framework your organization will use to achieve its sustainability goals. Devise two strategies you would have your company adopt, and explain why you believe..
|
|
Compute the heat required to convert
: Calculate the heat required (kJ) to convert 25.0 g of C2Cl3F3 from a liquid at 5*C to a gas at 82*C
|
|
Compare and contrast the ways in which act utilitarians
: The e-Activity presents two contrasting points of view. The employees who have been laid off and Weyco Incorporated have different interests and desires, and the decision made by Weyco to provide employees who smoke with an ultimatum-quit smoking ..
|
|
A solution of water and a nonvolatile nonionizing compound
: A solution of water and a nonvolatile, nonionizing compound is placed in a tube with a semipermeable membrane on one side. the tube is placed in a beaker of pure water. What initial net effect will occur?
|
|
Overall heat transfer coefficient
: Explain what is meant by an overall heat transfer coefficient and explain what is mean by failing and what its effect will be on the value of the overall heat transfer coefficient.
|
|
Explain the vapor pressure of the solution
: salt solution sits in an open beaker. Assuming constant temperature and pressure, the vapor pressure of the solution
|
|
What is the regulation or statute for
: How do you propose to enact these standards when you are an administrator? What is the regulation or statute for? Who does the act protect? What are the consequences for violating it? Why are laws like this good for protection? How do you propose..
|
|
In the cooper and shepard experiment
: In the Cooper and Shepard experiment (1973), participants were asked to decide whether a stimulus (a letter) was normal (simply rotated in the picture plane) or backwards (flipped to its mirror image before the rotation).
|
|
Annual food service convention
: The National Restaurant Association holds an annual food service convention in Chicago every year. This is a coveted event for many vendors to restaurants and hotels. Since this is an established event, there are hundreds of vendors at the trade show..
|