Reference no: EM131070086
1. The following sample information was obtained by taking four doughnuts per hour for twelve hours from Fawcett Bakery's doughnut process and weighing them:
Hour
|
WEIGHTS (GRAMS)
|
1
|
110, 105, 98, 100
|
2
|
79, 102, 100, 104
|
3
|
100, 102, 100, 96
|
4
|
94, 98, 99, 101
|
5
|
98, 104, 97, 100
|
6
|
104, 97, 99, 100
|
7
|
89, 102, 101, 99
|
8
|
100, 101, 98, 96
|
9
|
98, 95, 101, 100
|
10
|
99, 100, 97, 102
|
11
|
102, 97, 100, 101
|
12
|
98, 100, 100, 97
|
For the data shown above,
a) Find the x- and R for each sample.
b) Find the x-and R- for the twelve samples.
c) Find the 3-sigma UCL for the mean and range charts.
d) Does the process appear to be in statistical control. Why or why not?
2. Ten customers per hour were asked by the cashier at Stanley's Deli if they liked their meal, and the fraction that said "no" are shown below, for a twelve-hour period.
Hour
|
Fraction Defective
|
1
|
0
|
2
|
0.2
|
3
|
0.4
|
4
|
0.1
|
5
|
0.1
|
6
|
0.2
|
7
|
0.1
|
8
|
0
|
9
|
0
|
10
|
0.2
|
11
|
0
|
12
|
0.1
|
For the data shown above, find
a) P-
b) σp.
c) The 3-sigma UCL and LCL.
d) Does customer satisfaction at Stanley's appear to be in statistical control? How could we improve the analysis?
3. Roberto's Steakhouse tracks customer complaints every day and then follows up with its customers to resolve problems. For the past thirty days, it received a total of twenty complaints from unhappy customers. Using this information, calculate the 3-Sigma control limits.
Define the unknown quantity in terms of one variable
: Jackson's scores on the first four algebra quizzes are 76, 87, 92, and 71. What score must he earn on the fifth quiz to earn an average quiz score of 85? Define the unknown quantity in terms of one variable
|
Consist of three isomeric lactones
: A certain sample was analyzed by proton NMR and found to consist of three isomeric lactones (lactone Ahas a boiling point of 173°C; lactone B has a boiling point of 143°C; lactone C has a boiling point of 185°C).
|
Cooling of the fired crucible
: During the cooling of the fired crucible, water vapor condensed on the crucible wall before its mass measurement. The condensation did not occur following thermal decomposition of the hydrated salt in part b. Will the percent water in the hydrate..
|
Define cmd protocol-handshake and error messages
: Create two subsystems, where each subsystem executes on separate Micro Controller Units (MCU). One subsystem represents the Engine Management System (EMS) and the other the Engine Control Unit (ECU).The system is to emulate an Engine Control Syste..
|
Find the 3-sigma ucl for the mean and range charts
: Find the x-and R- for the twelve samples. Find the 3-sigma UCL for the mean and range charts. Does the process appear to be in statistical control. Why or why not
|
What would be the distance traveled by a 40 mm
: A 200 mm dia particle requires approximately 4 s to solidify during atomization and travels 1 m during this time. What would be the distance traveled by a 40 mm dia particle of the same material before solidification under the same conditions?
|
Most abundant element in the universe
: In terms of mass, name the fouth most abundant element in the universe.
|
Summarize the raw data from calibrating your salinity sensor
: Complete the electrical power system for the fish tank. At the start of class, the instructor will evaluate your electrical power system according to Checklist 2, which is available on the Homework page of the class web site.
|
Effect on solubility of a sparingly soluble salt
: What is the effect on solubility of a sparingly soluble salt when an uncommon electrolyte is added to the solution?
|